说明:双击或选中下面任意单词,将显示该词的音标、读音、翻译等;选中中文或多个词,将显示翻译。
您的位置:首页 -> 词典 -> 恒沸精馏法
1)  constant boiling rectification method
恒沸精馏法
1.
Production of anhydrous alcohol by constant boiling rectification method has already presented its advantages such as highly-developed mechanization, high yield, high quality and low production costs.
恒沸精馏法生产无水酒精能形成规模化生产 ,机械化程度高、产量大、质量好、消耗低。
2)  azeotropic distillation
恒沸精馏
1.
Study on technology of making anhydrous ethanol by ternary azeotropic distillation and application of conjugate ring;
三元恒沸精馏生产无水乙醇工艺研究及共轭环的应用
2.
And through azeotropic distillation,a 99.
80%环己烷产品;异丙醇水溶液经恒沸精馏得纯度为99。
3.
In this article,multiple steady states in ternary homogeneous azeotropic distillation have been studied.
研究三元均相恒沸精馏多定态现象,进行含有多个精馏区域的三角形相图的多定态分析。
3)  heat pump rectification
热泵恒沸精馏
1.
The principle, advantage and energy consumption problem of the new fuel alcohol technology using heat pump rectification are studied.
为解决传统燃料乙醇生产过程中能耗大的问题 ,将热泵技术与传统恒沸精馏工艺相结合 ,开发出热泵恒沸精馏生产新工艺。
4)  azeotropic distillation
恒沸蒸馏
1.
Experimental studies on desiccating the gel of ultra-fine SiO_2 by azeotropic distillation;
利用恒沸蒸馏干燥超细二氧化硅凝胶的研究
5)  azeotropic distillation
共沸精馏
1.
Study on production of dehydration ethanol with azeotropic distillation dividing-wall column;
用共沸精馏隔壁塔生产无水乙醇的研究
2.
Simulation of dividing-wall azeotropic distillation column for separation of tert-butanol from water
分隔壁共沸精馏塔分离叔丁醇水混合物的模拟研究
3.
Study of the entrainer of n-Butyl acetate in azeotropic distillation simulation for acetic Acid-water system
HAC-H_2O共沸精馏过程中共沸剂醋酸正丁酯的模拟研究
6)  azeotropic rectification
共沸精馏
1.
Esterifing synthesis of isopentyl acetate by a new equipment of water separation from azeotropic rectification;
共沸精馏分水酯化新装置合成乙酸异戊酯
2.
A new esterification equipment of combining microwave heating and water separation from azeotropic rectification solves the problem of the reaction quickly under the condition of microwave but water separation slowly This equipment can synthesize butyl ester rosin within 2 hours.
利用硫酸作催化剂 ,在微波加热与共沸精馏分水联合的新型酯化反应装置中合成松香丁酯。
3.
The esterification set with a water separator in azeotropic rectification is developed to enhance the conversion of lactic acid and reduce the time of synthetic reaction of ethyl lactate under the condition of resin catalyst.
使用带共沸精馏分水的酯化反应实验装置 ,在树脂酸催化剂的作用下合成乳酸乙酯 ,乳酸的转化率达到88%以上 ,最佳实验条件为乙醇与乳酸的物质的量比为 4∶ 1、催化剂用量为乳酸用量的 13%、反应时间为 2 70min。
补充资料:恒沸精馏
      向精馏塔内加入能与料液中被分离组分形成低沸点恒沸物(见汽液平衡)的添加剂,使普通精馏难以分离的液体混合物变得容易分离的一种特殊精馏方法。当料液中组分间的相对挥发度接近于1或形成恒沸物时,加入能与料液中一个或几个组分形成低沸点的恒沸物的添加剂,使被分离组分间的相平衡关系发生下列变化:①如果料液本来不会形成恒沸物,则形成沸点比各组分均低的恒沸物。这样,就可以用蒸馏的方法使之与其余组分分离。②如果料液的某些组分能够形成恒沸物,则与添加剂形成的新恒沸物的沸点低于原恒沸物。这样,添加剂的加入使料液中的一个组分全部进入恒沸物,从塔顶馏出,而塔底则可得到基本不含该组分的产物。若馏出的恒沸物的冷凝液是非均相的,则先用倾析,再用普通精馏进一步分离。如果馏出的恒沸物的冷凝液是均相的,需用萃取等方法分离。
  
  工艺流程  例如料液为苯(沸点为80.1℃)与环己酮(沸点为80.8℃)的混合液,用丙酮作添加剂,与料液一起加入塔内(见图)。环己酮与丙酮形成恒沸物从塔顶馏出,从塔底可得纯苯。恒沸物(沸点为50.3℃)与纯苯的沸点相差颇大,使精馏过程容易进行。塔顶馏出的恒沸物是均相的,可用水萃取丙酮,留下纯环己酮。丙酮再经精馏回收,供循环使用。
  
  如果料液本身能形成非均相恒沸物,也可不用添加剂而采用双塔流程进行分离。这种精馏过程也属于恒沸精馏。例如,原料液为稀糠醛水溶液,在第一塔中进行常压精馏,糠醛可以全部进入恒沸物,从塔顶馏出,塔底得纯水。恒沸物经冷凝后分成两个液层:上层为水相(糠醛的摩尔分率约0.02)作为第一塔的回流;下层为醛相(糠醛的摩尔分率约0.7),进入第二塔中再次精馏。第二塔的馏出物为恒沸组成,在塔底得纯糠醛。
  
  添加剂的选择  恒沸添加剂又称夹带剂,选择的原则是:①添加剂至少与料液中一个组分能形成低沸点恒沸物;②在所形成的恒沸物中,添加剂的相对含量不应太多,以减少添加剂的需用量;③添加剂应与料液中含量少的组分形成恒沸物,以减轻精馏过程的热负荷;④来源充足,价格便宜,且安全无毒。
  
  恒沸精馏主要用于各种有机物的脱水以及醛、酮、有机酸及烃类氧化物等的分离。与萃取精馏相比,恒沸添加剂的选择范围较小,且添加剂由塔顶馏出,热耗较大。只有当添加剂与原料中含量较少的组分形成恒沸物时,采用恒沸精馏才是经济的。
  

说明:补充资料仅用于学习参考,请勿用于其它任何用途。
参考词条