说明:双击或选中下面任意单词,将显示该词的音标、读音、翻译等;选中中文或多个词,将显示翻译。
您的位置:首页 -> 词典 -> 真空低温连续干燥
1)  vacuum low-temperature continuous drying
真空低温连续干燥
1.
Through the process analysis and key technologies research of the production line for the vacuum low-temperature continuous drying,a low-temperature vacuum drying industrial automation production line for high moisture corn was established with a output of 300t/d.
通过对真空低温连续干燥生产线工艺性分析和关键技术研究,建立了300t/d高水分玉米真空低温连续干燥工业自动化生产线,并对生产线系统进行了生产性试验和关键技术验证分析。
2.
This article introduced the development backgroung of new vacuum low-temperature continuous dryingtechnology.
介绍了真空低温连续干燥新技术的发展背景,通过技术性分析,探索出了一条解决粮食干燥问题的新途径。
2)  Continuous Vacuum Drying
真空连续干燥
3)  continuous vacuum drying
连续真空干燥
1.
Fuzzily comprehensive evaluation for design specification of continuous vacuum drying process;
塔型连续真空干燥设计方案的模糊综合评价
4)  vacuum dehydrating at lower temperature
真空低温干燥
1.
Non-frying crisp chip of chaenomeles were processed by vacuum infusing and vacuum dehydrating at lower temperature, the products keep its original color, taste and high Vc content, the products is bright-color, plump slice and harmonious sweet and acid, rich in chaenomeles flavor.
应用真空糖渍和真空低温干燥技术对新鲜木瓜进行加工,研制具有天然水果色、香、味的无油木瓜脆片。
2.
Several high quality convenience foods of preserved actinidia chinensis have been processed by vacuum infusing and vacuum dehydrating at lower temperature.
应用真空浸渍和真空低温干燥技术对鲜猕猴桃进行加工, 可获得保持原有色泽、口感,酸甜适宜、Vc含量分别高达 560mg/100g和468mg/100g的干制品和果脯。
5)  low-temperature vacuum drying
低温真空干燥
1.
Based on the theoretical analyses of water potential,a mathematical model of low-temperature vacuum drying was developed.
基于水势理论分析,建立了谷物低温真空干燥的数学模型。
6)  cinctured continuous vacuum dryer
带式连续真空干燥
1.
The dehydrating characters of banana powder by cinctured continuous vacuum dryer were studied.
对带式连续真空干燥条件下香蕉粉的失水特性进行研究。
补充资料:zd真空低温自动干燥机组

 

   概 述 
    前我国中药制药行业在中药浸膏干燥过程中存在着高温干燥、热敏性药物变性、间歇操作、容易染菌、干燥时间长、能耗高,达不到GMP要求等诸多不尽如人意的地方,针对这种现状,我公司研制开发了真空低温自动干燥系列机组。
    真空低温自动干燥机是为中药浸膏脱水成多孔速溶颗粒专题设计制造的系列干燥机。由于中药浸膏在真空状态低温干燥后具有多孔、松脆、含水量低的特点,因而本干燥机制成的颗粒可直接作为速溶;中剂、充填胶囊、轧片、涂膜中间体等的原料。
    本干燥机能成功干燥粘度很高(一万厘泊左右)的中药浸膏,同时也适用于麦乳精、果珍、咖啡、速溶奶粉、速溶茶及高吸水性树脂等物料的干燥。 
    物料在机内真空腔中干燥过程中不与大气接触,并且换热后的二次蒸汽迅速由真空泵抽去,因而保证了物质的洁净。同时物料中水份在真空条件下低温蒸发能节约换热的能源并且高质量地完成高粘度物料的干燥。
 
    特 点 
1.本机加热源可采用蒸汽.亦可采用电加热转换导热油加热
2.干燥过程物料温度低于50°C,25分钟后开始出颗粒直至批量完成
3.以螺杆泵定量恒速进料(进料量可按需设定)
4.履带运转平稳、可靠(履带速度可按需设定)
5.自动制粒,真空状态连续排出干颗粒至贮料桶内,真空状更换干颗粒贮料桶
6. 能耗小、无三废、低噪声
7.可自动清洗、快速方便,完成干燥内腔清洗:
8.完全符合GMP要求。

型号及外形尺寸表

型号
直径mm
长度mm
高度mm
真空腔容积m3
ZD101
ø1920
9540
2970
26.1
ZD102
ø1922
15540
2972
43.1
ZD103
ø1924
20040
2974
55.9
ZD104
ø1924
25540
2974
71.5

    型号及基本参数表

基本参数/型号
ZD101
ZD102
ZD103
ZD104
进料速度L/h
20-40
36-72
48-96
63-126
进料温度°C
<=70
<=70
<=70
<=70
进料含水率%
<=50
<=50
<=50
<=50
履带速度m/min
0.35
0.63
0.84
1.10
干燥成品含水率%
<=4
<=4
<=4
<=4
产量kg/h
12-36
21.6-64.8
28.8-86.4
37.8-113.4
工作电源
380V,50Hz
380V,50Hz
380V,50Hz
380V,50Hz
配电功率kw
16
20
22
22
热源
蒸汽或电热
蒸汽或电热
蒸汽或电热
蒸汽或电热
清洗系统工作压力MPa
0.3MPa
0.3MPa
0.3MPa
0.3MPa
说明:补充资料仅用于学习参考,请勿用于其它任何用途。
参考词条